{"id":54452,"date":"2013-03-01T10:24:41","date_gmt":"2013-03-01T15:24:41","guid":{"rendered":"http:\/\/motorcyclemojo.com\/?p=54452"},"modified":"2020-04-07T11:31:04","modified_gmt":"2020-04-07T15:31:04","slug":"charging-system-checklist","status":"publish","type":"post","link":"https:\/\/motorcyclemojo.com\/2013\/03\/charging-system-checklist\/","title":{"rendered":"Charging System Checklist"},"content":{"rendered":"

You probably take it for granted that when you push the starter button on your bike, it\u2019ll turn over and fire up. My girlfriend and I were taken by surprise before a ride recently, when her SV650 refused to turn over. It had been parked for a couple of weeks, but that wasn\u2019t long enough to allow the battery, which had been replaced at the beginning of the season, to drain. I suspected a problem with the charging system, and after a couple of tests, I was proven right.<\/p>\n

All modern motorcycles operate on a 12-volt DC (direct current) charging system, which consists of three main components: a battery, an alternator and a regulator.<\/p>\n

\"\"The battery stores the energy needed to start the bike and operate all of the electrical components, even when the bike is running. The alternator provides unregulated AC (alternating current) electricity, which is eventually used to maintain the battery\u2019s charge while the bike is running. The regulator, a small finned box, performs two functions: it regulates the voltage leaving the alternator, which increases with engine revs to approximately 12 volts, and it converts alternating current to direct current.<\/p>\n

Aside from a service manual and a couple of basic hand tools to access the various charging system components, the only other item you\u2019ll need to verify the charging system is a multimeter with AC\/DC voltmeter and ohmmeter functions. But before performing any tests on the charging system, make sure the battery fluid is at the proper level (no need to check this on a maintenance-free battery), and that it is fully charged. A charging system, despite its name, will not charge a dead battery, and a good battery is needed to perform the various tests.<\/p>\n

To be sure the battery is charged, attach a battery charger to it. Once the battery is fully charged, it should read more than 13 volts DC. Even though motorcycle electrical systems are rated at 12 volts, they actually operate at more than 14 volts when the engine is running. Note that a reading of 13 volts at the battery isn\u2019t necessarily an indication that it is in good condition, but it\u2019s enough power to start the bike and perform charging-system tests. A proper battery test should be performed using a load tester, usually found at auto and motorcycle shops.<\/p>\n

\"\"To test the charging system, run the engine and place the multimeter leads (reading DC volts) across the battery terminals. With the engine revving at about 3000 rpm, the voltage should read more than 13.5 volts but not more that 15 volts. On the SV, voltage at idle was about 13 volts, which is normal, but when the engine was revved, the voltage actually dropped, reading about 12.5 volts at 3000 rpm or more. This told me that further testing was needed.<\/p>\n

The next item to verify is the alternator. Locate the alternator connector plug \u2013 it usually has three large-gauge wires coming off the stator, and most of the time they\u2019re yellow. With the ignition off, disconnect the plug and attach the multimeter leads (in the ohmmeter function) to any two of the three wires on the alternator side. The service manual will tell you what the resistance should be when you check any two of the three wires (0.2-0.55 \u03a9 for the SV), and they should all have similar readings. Also check between each wire and ground by connecting one lead to one wire and the other lead to a metal part of the bike. Any resistance here means there is a problem; it should be an open circuit.<\/p>\n

There\u2019s one more check to perform on the alternator. With the engine running, connect the multimeter leads (meter set to AC voltage) to any two alternator wires while revving the engine. Again, the specs here vary, but the stator should produce about 10 to 15 volts AC for every 1000 rpm. My SV read 72 volts at 5000 rpm, so it was fine.<\/p>\n

Since the SV registered only 12.5 volts at the battery with engine revving, the alternator passed all tests, and all wires and connectors proved intact, the only culprit left was the regulator. There is a procedure in the manual to check all the wires coming out of the regulator, but I was confident enough in my testing procedure that I skipped this step.<\/p>\n

I ordered an aftermarket unit through a Canadian distributor at one-third the cost of the OEM regulator, plugged it in and immediately got 14.2 volts across the battery terminals at 2000 rpm.<\/p>\n

If the SV had passed the battery voltage test with the engine running, the next thing I\u2019d have checked is the current draw with the engine off. For this you must disconnect the negative terminal and place the multimeter between the negative battery post and the negative battery terminal. (It must read in milliamps [mA] for this test.) According to the SV manual, a reading of more than 1 mA indicates a problem, and the battery will drain prematurely. If you see a noticeable spark when you disconnect the negative terminal, you may need a multimeter that reads more amperage, say 10-amp, although a smaller meter should be protected by a fuse to prevent any damage.<\/p>\n

Also, if you\u2019ve added electrical accessories, or maybe if you use heated riding gear, you must make sure that you are not overwhelming the charging system with all of the accessories operating. Again, here, the voltmeter is your friend. Perform the voltage test, engine revving, with the voltmeter leads connected across the battery, but this time with all accessories turned on or plugged in. If the voltage drops with the engine revving, you\u2019re taxing the charging system too much. Either manage your accessory usage or remove some of the stuff.<\/p>\n

Lastly, to avoid embarrassment, make sure you didn\u2019t last leave your bike with the parking light on. Don\u2019t ask me how I found this out.<\/p>\n

Technical articles are written purely as reference only and your motorcycle may require different procedures. You should be mechanically inclined to carry out your own maintenance and we recommend you contact your mechanic prior to performing any type of work on your bike.<\/em><\/p>\n","protected":false},"excerpt":{"rendered":"

You probably take it for granted that when you push the starter button on your bike, it\u2019ll turn over and fire up. My girlfriend and I were taken by surprise before a ride recently, when her SV650 refused to turn over. It had been parked for a couple of weeks, but that wasn\u2019t long enough […]<\/p>\n","protected":false},"author":1,"featured_media":54453,"comment_status":"open","ping_status":"closed","sticky":false,"template":"","format":"standard","meta":{"ngg_post_thumbnail":0,"footnotes":""},"categories":[138,1877],"tags":[],"yoast_head":"\nMotorcycle Charging System Checklist | Motorcycle Mojo<\/title>\n<meta name=\"description\" content=\"In this month's issue of Motorcycle Mojo magazine, we provide you with a checklist to make sure that your motorcycle charging system is working properly.\" \/>\n<meta name=\"robots\" content=\"index, follow, max-snippet:-1, max-image-preview:large, max-video-preview:-1\" \/>\n<link rel=\"canonical\" href=\"https:\/\/motorcyclemojo.com\/2013\/03\/charging-system-checklist\/\" \/>\n<meta property=\"og:locale\" content=\"en_US\" \/>\n<meta property=\"og:type\" content=\"article\" \/>\n<meta property=\"og:title\" content=\"Motorcycle Charging System Checklist | Motorcycle Mojo\" \/>\n<meta property=\"og:description\" content=\"In this month's issue of Motorcycle Mojo magazine, we provide you with a checklist to make sure that your motorcycle charging system is working properly.\" \/>\n<meta property=\"og:url\" content=\"https:\/\/motorcyclemojo.com\/2013\/03\/charging-system-checklist\/\" \/>\n<meta property=\"og:site_name\" content=\"Motorcycle Mojo\" \/>\n<meta property=\"article:publisher\" content=\"https:\/\/www.facebook.com\/MOTORCYCLE-MOJO-MAGAZINE-161377162001\/\" \/>\n<meta property=\"article:published_time\" content=\"2013-03-01T15:24:41+00:00\" \/>\n<meta property=\"article:modified_time\" content=\"2020-04-07T15:31:04+00:00\" \/>\n<meta property=\"og:image\" content=\"https:\/\/motorcyclemojo.com\/wp-content\/uploads\/2020\/04\/diconnected_negative_terminal.jpg\" \/>\n\t<meta property=\"og:image:width\" content=\"1000\" \/>\n\t<meta property=\"og:image:height\" content=\"750\" \/>\n\t<meta property=\"og:image:type\" content=\"image\/jpeg\" \/>\n<meta name=\"author\" content=\"Mojo\" \/>\n<meta name=\"twitter:card\" content=\"summary_large_image\" \/>\n<meta name=\"twitter:creator\" content=\"@motorcyclemojo\" \/>\n<meta name=\"twitter:site\" content=\"@motorcyclemojo\" \/>\n<meta name=\"twitter:label1\" content=\"Written by\" \/>\n\t<meta name=\"twitter:data1\" content=\"Mojo\" \/>\n\t<meta name=\"twitter:label2\" content=\"Est. reading time\" \/>\n\t<meta name=\"twitter:data2\" content=\"5 minutes\" \/>\n<script type=\"application\/ld+json\" class=\"yoast-schema-graph\">{\"@context\":\"https:\/\/schema.org\",\"@graph\":[{\"@type\":\"WebPage\",\"@id\":\"https:\/\/motorcyclemojo.com\/2013\/03\/charging-system-checklist\/\",\"url\":\"https:\/\/motorcyclemojo.com\/2013\/03\/charging-system-checklist\/\",\"name\":\"Motorcycle Charging System Checklist | Motorcycle Mojo\",\"isPartOf\":{\"@id\":\"https:\/\/motorcyclemojo.com\/#website\"},\"datePublished\":\"2013-03-01T15:24:41+00:00\",\"dateModified\":\"2020-04-07T15:31:04+00:00\",\"author\":{\"@id\":\"https:\/\/motorcyclemojo.com\/#\/schema\/person\/34e2f2e71d83920226c959f06fd24cdd\"},\"description\":\"In this month's issue of Motorcycle Mojo magazine, we provide you with a checklist to make sure that your motorcycle charging system is working properly.\",\"breadcrumb\":{\"@id\":\"https:\/\/motorcyclemojo.com\/2013\/03\/charging-system-checklist\/#breadcrumb\"},\"inLanguage\":\"en-US\",\"potentialAction\":[{\"@type\":\"ReadAction\",\"target\":[\"https:\/\/motorcyclemojo.com\/2013\/03\/charging-system-checklist\/\"]}]},{\"@type\":\"BreadcrumbList\",\"@id\":\"https:\/\/motorcyclemojo.com\/2013\/03\/charging-system-checklist\/#breadcrumb\",\"itemListElement\":[{\"@type\":\"ListItem\",\"position\":1,\"name\":\"Home\",\"item\":\"https:\/\/motorcyclemojo.com\/\"},{\"@type\":\"ListItem\",\"position\":2,\"name\":\"Charging System Checklist\"}]},{\"@type\":\"WebSite\",\"@id\":\"https:\/\/motorcyclemojo.com\/#website\",\"url\":\"https:\/\/motorcyclemojo.com\/\",\"name\":\"Motorcycle Mojo\",\"description\":\"\",\"potentialAction\":[{\"@type\":\"SearchAction\",\"target\":{\"@type\":\"EntryPoint\",\"urlTemplate\":\"https:\/\/motorcyclemojo.com\/?s={search_term_string}\"},\"query-input\":\"required name=search_term_string\"}],\"inLanguage\":\"en-US\"},{\"@type\":\"Person\",\"@id\":\"https:\/\/motorcyclemojo.com\/#\/schema\/person\/34e2f2e71d83920226c959f06fd24cdd\",\"name\":\"Mojo\",\"image\":{\"@type\":\"ImageObject\",\"inLanguage\":\"en-US\",\"@id\":\"https:\/\/motorcyclemojo.com\/#\/schema\/person\/image\/\",\"url\":\"https:\/\/secure.gravatar.com\/avatar\/4cc87f50d1fa4da0cf95de93394efdd4?s=96&d=mm&r=r\",\"contentUrl\":\"https:\/\/secure.gravatar.com\/avatar\/4cc87f50d1fa4da0cf95de93394efdd4?s=96&d=mm&r=r\",\"caption\":\"Mojo\"},\"sameAs\":[\"http:\/\/motorcyclemojo.com\"],\"url\":\"https:\/\/motorcyclemojo.com\/author\/admin\/\"}]}<\/script>\n<!-- \/ Yoast SEO plugin. -->","yoast_head_json":{"title":"Motorcycle Charging System Checklist | Motorcycle Mojo","description":"In this month's issue of Motorcycle Mojo magazine, we provide you with a checklist to make sure that your motorcycle charging system is working properly.","robots":{"index":"index","follow":"follow","max-snippet":"max-snippet:-1","max-image-preview":"max-image-preview:large","max-video-preview":"max-video-preview:-1"},"canonical":"https:\/\/motorcyclemojo.com\/2013\/03\/charging-system-checklist\/","og_locale":"en_US","og_type":"article","og_title":"Motorcycle Charging System Checklist | Motorcycle Mojo","og_description":"In this month's issue of Motorcycle Mojo magazine, we provide you with a checklist to make sure that your motorcycle charging system is working properly.","og_url":"https:\/\/motorcyclemojo.com\/2013\/03\/charging-system-checklist\/","og_site_name":"Motorcycle Mojo","article_publisher":"https:\/\/www.facebook.com\/MOTORCYCLE-MOJO-MAGAZINE-161377162001\/","article_published_time":"2013-03-01T15:24:41+00:00","article_modified_time":"2020-04-07T15:31:04+00:00","og_image":[{"width":1000,"height":750,"url":"https:\/\/motorcyclemojo.com\/wp-content\/uploads\/2020\/04\/diconnected_negative_terminal.jpg","type":"image\/jpeg"}],"author":"Mojo","twitter_card":"summary_large_image","twitter_creator":"@motorcyclemojo","twitter_site":"@motorcyclemojo","twitter_misc":{"Written by":"Mojo","Est. reading time":"5 minutes"},"schema":{"@context":"https:\/\/schema.org","@graph":[{"@type":"WebPage","@id":"https:\/\/motorcyclemojo.com\/2013\/03\/charging-system-checklist\/","url":"https:\/\/motorcyclemojo.com\/2013\/03\/charging-system-checklist\/","name":"Motorcycle Charging System Checklist | Motorcycle Mojo","isPartOf":{"@id":"https:\/\/motorcyclemojo.com\/#website"},"datePublished":"2013-03-01T15:24:41+00:00","dateModified":"2020-04-07T15:31:04+00:00","author":{"@id":"https:\/\/motorcyclemojo.com\/#\/schema\/person\/34e2f2e71d83920226c959f06fd24cdd"},"description":"In this month's issue of Motorcycle Mojo magazine, we provide you with a checklist to make sure that your motorcycle charging system is working properly.","breadcrumb":{"@id":"https:\/\/motorcyclemojo.com\/2013\/03\/charging-system-checklist\/#breadcrumb"},"inLanguage":"en-US","potentialAction":[{"@type":"ReadAction","target":["https:\/\/motorcyclemojo.com\/2013\/03\/charging-system-checklist\/"]}]},{"@type":"BreadcrumbList","@id":"https:\/\/motorcyclemojo.com\/2013\/03\/charging-system-checklist\/#breadcrumb","itemListElement":[{"@type":"ListItem","position":1,"name":"Home","item":"https:\/\/motorcyclemojo.com\/"},{"@type":"ListItem","position":2,"name":"Charging System Checklist"}]},{"@type":"WebSite","@id":"https:\/\/motorcyclemojo.com\/#website","url":"https:\/\/motorcyclemojo.com\/","name":"Motorcycle Mojo","description":"","potentialAction":[{"@type":"SearchAction","target":{"@type":"EntryPoint","urlTemplate":"https:\/\/motorcyclemojo.com\/?s={search_term_string}"},"query-input":"required name=search_term_string"}],"inLanguage":"en-US"},{"@type":"Person","@id":"https:\/\/motorcyclemojo.com\/#\/schema\/person\/34e2f2e71d83920226c959f06fd24cdd","name":"Mojo","image":{"@type":"ImageObject","inLanguage":"en-US","@id":"https:\/\/motorcyclemojo.com\/#\/schema\/person\/image\/","url":"https:\/\/secure.gravatar.com\/avatar\/4cc87f50d1fa4da0cf95de93394efdd4?s=96&d=mm&r=r","contentUrl":"https:\/\/secure.gravatar.com\/avatar\/4cc87f50d1fa4da0cf95de93394efdd4?s=96&d=mm&r=r","caption":"Mojo"},"sameAs":["http:\/\/motorcyclemojo.com"],"url":"https:\/\/motorcyclemojo.com\/author\/admin\/"}]}},"_links":{"self":[{"href":"https:\/\/motorcyclemojo.com\/wp-json\/wp\/v2\/posts\/54452"}],"collection":[{"href":"https:\/\/motorcyclemojo.com\/wp-json\/wp\/v2\/posts"}],"about":[{"href":"https:\/\/motorcyclemojo.com\/wp-json\/wp\/v2\/types\/post"}],"author":[{"embeddable":true,"href":"https:\/\/motorcyclemojo.com\/wp-json\/wp\/v2\/users\/1"}],"replies":[{"embeddable":true,"href":"https:\/\/motorcyclemojo.com\/wp-json\/wp\/v2\/comments?post=54452"}],"version-history":[{"count":0,"href":"https:\/\/motorcyclemojo.com\/wp-json\/wp\/v2\/posts\/54452\/revisions"}],"wp:featuredmedia":[{"embeddable":true,"href":"https:\/\/motorcyclemojo.com\/wp-json\/wp\/v2\/media\/54453"}],"wp:attachment":[{"href":"https:\/\/motorcyclemojo.com\/wp-json\/wp\/v2\/media?parent=54452"}],"wp:term":[{"taxonomy":"category","embeddable":true,"href":"https:\/\/motorcyclemojo.com\/wp-json\/wp\/v2\/categories?post=54452"},{"taxonomy":"post_tag","embeddable":true,"href":"https:\/\/motorcyclemojo.com\/wp-json\/wp\/v2\/tags?post=54452"}],"curies":[{"name":"wp","href":"https:\/\/api.w.org\/{rel}","templated":true}]}}